Fisheries and Aquatic Sciences
BioMed Central
Research Article

# Chemical composition of protein concentrate prepared from Yellowfin tuna Thunnus albacares roe by cook-dried process

Hyun Ji Lee1, Sung Hwan Park1, In Seong Yoon1, Gyoon-Woo Lee1, Yong Jung Kim2, Jin-Soo Kim2, Min Soo Heu1,*
1Department of Food and Nutrition/Institute of Marine IndustryGyeongsang National University52828JinjuKorea
2Department of Seafood Science and Technology/Institute of Marine IndustryGyeongsang National University53064TongyeongKorea
*+82.55.772.1440heu1837@dreamwiz.com

Received: Mar 20, 2016; Accepted: Apr 1, 2016

Published Online: May 10, 2016

## Abstract

Roe is the term used to describe fish eggs (oocytes) gathered in skeins and is one of the most valuable food products from fishery sources. Thus, means of processing are required to convert the underutilized yellowfin tuna roes (YTR) into more marketable and acceptable forms as protein concentrate. Roe protein concentrates (RPCs) were prepared by cooking condition (boil-dried concentrate, BDC and steam-dried concentrate, SDC, respectively) and un-cooking condition (freeze-dried concentrate, FDC) from yellowfin tuna roe. The yield of RPCs was in the range from 22.2 to 25.3 g/100 g of roe. RPCs contained protein (72.3–77.3 %), moisture (4.3–5.6 %), lipid (10.6–11.3 %) and ash (4.3–5.7 %) as the major constituents. The prominent amino acids of RPCs were aspartic acid, 8.7–9.2, glutamic acid, 13.1–13.2, and leucine, 8.5–8.6 g/100 g of protein. Major differences were not observed in each of the amino acid. K, S, Na, and P as minerals were the major elements in RPCs. No difference noted in sodium dodecyl sulfate polyacrylamide gel electrophoresis protein band (15–100 K) possibly representing partial hydrolysis of myosin. Therefore, RPCs from YTR could be use potential protein ingredient for human food and animal feeds.

Keywords: Protein concentrate; Roe; Yellowfin tuna; Chemical composition; Cook-dried process

## Background

Yellowfin tuna Thunnus albacares is a large tuna species found in the Pacific, Indian and Atlantic oceans. It is an important component of tuna fisheries worldwide and is one of the major target species for the tuna fishery in the major oceans, and popularly catched marine fish with annual availability of 44,013 t on overseas fishery in Korea during 2013 (Ministry of Ocean and Fisheries 2014). It is used extensively in raw cuisine such as sushi and sashimi. Byproducts such as scales, heads, skin, fat, visceral, and roe are generated increasingly and discarded as waste, without any attempt to recover the essential nutrients (Chalamaiah et al. 2010). Among by-products, roes are highly nutritious material rich in essential fatty acids and amino acids (Heu et al. 2006; Narsing Rao et al. 2012b). Fish roes are produced in large quantities during the spawning seasons, which constitute about 1–3 % of the weight of fish (Chalamaiah et al. 2013; Klomklao et al. 2013; Intarasirisawat et al. 2011). Currently roe obtained from fish such as salmon, cod, and pollock have a potential commercial market, especially they have a higher demand in Asian countries (Sathivel et al. 2009). Yellowfin tuna roe is an abundant and underutilized byproduct that can be used as a unique protein source (Heu et al. 2006). The roe can be used to recover protein that may be converted into a higher value food ingredient suitable for use as an emulsifier in food and feed systems (Sathivel et al. 2009).

Protein concentrates are widely used as ingredients in food industry because of their high nutritional quality, functional properties, high protein level and low content of antinutritional factors (Cordero-de-los-Santos et al. 2005). Using fish proteins in powder form presents some advantages since they do not require special storage conditions and they can also easily be used as an ingredient in foods (Pires et al. 2012). Drying preserves fish by inactivation enzymes and removing the moisture necessary for bacterial and mold growth (Bellagha et al. 2002; Bala and Mondol 2001; Duan et al. 2004). Recently, protein concentrate preparation have been reported for different protein sources such as roe of Channa striatus and Lates calcarifer (Narsing Rao et al. 2012a), byproducts of Alaska pollock (Sathivel and Bechtel 2006), mrigal egg (Chalamaiah et al. 2013) and roes of hake and ling (Rodrigo et al. 1998).

Before the drying process, boiling and steaming of fish improve their digestibility, enhances palatability, and provide a safe eating by killing harmful bacteria, other micro-organisms and parasites. Thus, means of processing are required to convert the underutilized yellowfin tuna roes into more marketable and acceptable forms as protein concentrate. There is no information about protein concentrate by cook-dried process. The objectives of this study were to investigate chemical characteristic for protein concentrate from yellowfin tuna roe prepared by cook-dried process and to identify possibility on utilization of 2’nd byproduct. Hence, we expected that full utilization for fish roe concentrate will be possible by reducing the 2’nd byproduct wastage and environmental pollution.

## Methods

Raw material

Yellowfin tuna Thunnus albacares roe was obtained from Dongwon F&B Co., Ltd. (Changwon, Korea). Roe was stored at −70 °C in sealed polyethylene bags, and transferred to the laboratory. Frozen roe was partially thawed for 24 h at 4 °C and then cut into small pieces with an approximate thickness of 1.5–3 cm and minced with food grinder (SFM-555SP, Shinil Industrial Co., Ltd., Seoul Korea). Minced roe was frozen at −20 °C until used.

Chemicals

Sodium dodecyl sulfate (SDS) and glycine were purchased from Bio Basic Inc., (Ontario, Canada). Coomassie Brilliant Blue R-250 was purchased from Bio-Rad Laboratories (Hercules, CA, USA). Bovine serum albumin (BSA), β-Mercaptoethanol (β-ME), egg white, glycerol, N,N,N′,N′-tetramethyl ethylene diamine (TEMED), sodium carbonate, sodium hydroxide, sodium L-tatarate, and potassium hydroxide were purchased from Sigma-Aldrich Co., Ltd. (St. Louis, MO, USA). Copper (II) sulfate pentahydrate was purchased from Yakuri Pure Chemicals Co., Ltd. (Kyoto, Japan). Bromophenol blue and Folin-Ciocalteu’s reagent were purchased Junsei Chemical Co., Ltd. (Tokyo, Japan). All reagents used analytical grade.

Preparation of roe protein concentrates (RPCs)

300 g of frozen minced roe was put into pouch type tea bag (polyethylene polypropylene, 16 × 14.5 cm) for cook-dried process. Freeze-dried concentrate (FDC) as an un-cooked sample was prepared using freeze dryer (PVTFD50A, ilShinbiobase Co., Ltd., Dongducheon, Korea). To prepare the boil-dried concentrate (BDC), sample immerged in five volume of distilled deionized water (DDW) and was boiled for 20 min after sample core temperature was reached to 80 °C. In case of steam-dried concentrate (SDC), sample was steamed for 20 min after sample core temperature was reached to 80 °C. Cooked (boiled or steamed) samples were dried at 70 ± 1 °C for 15 h using an incubator (VS-1203P3V, Vision Scientific, Co., Ltd., Daejeon, Korea). Boil or steam-dried samples were ground to powder using a food grinder and sieved to pass through a 180 mesh to obtained dehydrated RPCs. Grounded powders were referred to as BDC and SDC, respectively. During these processes, cooking process drips such as boil-process drip (BPD) and steam-process drip (SPD) were generated as the 2’nd byproduct. They were packed in plastic bottles and stored at −20 °C for further experiments. A flow chart for the preparation of roe protein concentrates (RPCs) is shown in Fig. 1.

Fig. 1. Flowchart of preparation of roe protein concentrates (RPCs) prepared by cook-dried process

Proximate composition

The proximate composition was determined according to the AOAC method (AOAC 1995). Moisture content was determined by placing accurately weighed 0.2 g of sample into an aluminum pan. Sample was dried in a forced-air convection oven (WFO-700, EYELA, Tokyo, Japan) at 105 °C until a constant weight was reached. The ash content was determined by charring approximately 0.1 g of sample in a ceramic crucible over a hot plate and then heating in a muffle furnace (Thermolyne 10500 furnace, a subsidiary of Sybron Co., Dubuque, IA, USA) at 550 °C until a constant final weight for ash was achieved. The total crude protein (nitrogen x 6.25) content of samples was determined using the semi-micro Kjeldahl method. Protein concentration of cooking process drips was determined by the method of Lowry et al. (1951) using bovine serum albumin as a standard. Total lipid content was determined according to the Soxhlet extraction method. 5 g of sample was extracted with dimethyl ether and performed for 30 min at a drip rate of 10 mL/min. Total lipid content was determined on a gravimetric basis and expressed as percent.

Total amino acid

Total amino acid analysis was conducted according to AOAC method (AOAC 1995). The sample (20 mg) was hydrolyzed with 2 mL of 6 N HCl at 110 °C for 24 h in heating block (HF21, Yamoto Science Co, Tokyo, Japan) and filtered out using vacuum filtrator (ASPIRATOR A-3S, EYELA, Tokyo, Japan). Amino acids were quantified using the amino acid analyzer (Biochrom 30, Biochrom Ltd., Cambridge, United Kingdom) employing sodium citrate buffers (pH 2.2) as step gradients. The data are reported as g of amino acid per 100 g of protein. Asparagine is converted to aspartic acid and glutamine to glutamate during acid hydrolysis, so the reported values for these amino acids (Asp and Glu) represent the sum of the respective amine and amino acid in the proteins.

Mineral

Analysis of iron (Fe), copper (Cu), manganese (Mn), cadmium (Cd), nickel (Ni), lead (Pb), zinc (Zn), chromium (Cr), magnesium (Mg), sodium (Na), phosphorus (P), potassium (K), calcium (Ca), and sulfur (S) contents in sample was carried out using the inductively coupled plasma optical emission spectrophotometry (OPTIMA 4300 DV, Perkin Elmer, Shelton, Conn., USA). Briefly, teflon digestion vessel was washed overnight in a solution of 2 % nitric acid (v/v) prior to use.

Sample was dissolved in 10 mL of 70 % nitric acid. The mixture was heated on the hot plate until digestion was completed. The digested samples were added in 5 mL of 2 % nitric acid and filtered using filter paper (Advantec No. 2, Toyo Roshi Kaisha, Ltd., Tokyo, Japan). Sample was massed up to 100 mL with 2 % nitric acid in a volumetric flask. Sample was run in triplicate. The concentration of mineral was calculated and expressed as mg/100 g sample.

Hunter color

Hunter color properties of samples were equilibrated to room temperature for 2 h prior to the color measurement. Colors were determined using color meter (ZE-2000, Nippon Denshoku Inc., Japan). The colorimeter was calibrated by using a standard plate (L* = 96.82, a* = −0.35, b* = 0.59) supplied by the manufacturer. The values for the CIE (Commission Internationale d’Eclairage of France) color system using tristimulus color values, L* (lightness), a* (redness), and b* (yellowness) were determined. The whiteness was calculated by the following equation:

$\mathrm{White}\phantom{\rule{0.25em}{0ex}}\mathrm{index}=100-\sqrt{{\left(100-L\right)}^{2}+{a}^{2}+{b}^{2}}$

SDS-PAGE

The molecular weight distribution of YTR and RPCs was observed by sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS–PAGE). It was performed according to the method of Laemmli (1970). Briefly, 10 mg of sample was solubilized in 1 mL of 8 M urea solution containing 2 % β-mercaptoethanol and 2 % sodium dodecyl sulfate (SDS) solution. Protein solution was mixed at 4:1 (v/v) ratio with the SDS-PAGE sample treatment buffer (62.5 mM Tris–HCl (pH 6.8), 2 % SDS (w/v), 10 % glycerol, 2 % β-mercaptoethanol and 0.002 % bromophenol blue) and boiled at 100 °C for 3 min. The sample (20 μg protein) was loaded on the 10 % Mini-PROTEAN® TGX™ Precast gel (Bio-Rad Lab., Inc., Hercules, CA, USA) and subjected to electrophoresis at a constant current of 10 mA per gel using a Mini-PROTEANⓇ tetra cell (Bio-Rad Lab., Inc., Hercules, CA, USA).

Electrophoresed gel was stained in 0.125 % Coomassie brilliant blue R-250 and destained in 25 % methanol and 10 % acetic acid until background was clear. Molecular weight of protein bands was estimated using Precision Plus Protein™ standards (10–250 K, Bio-Rad Lab., Inc., Hercules, CA, USA).

Statistical analysis

All experiments were conducted in triplicates. The average and standard deviation were calculated. Data were analyzed using analysis of variance (ANOVA) procedure by means of the statistical software of SPSS 12.0 KO (SPSS Inc., Chicago, IL, USA). The mean comparison was made using the Duncan’s multiple range test (P < 0.05).

## Results and discussions

Proximate composition

Proximate compositions of yellowfin tuna roe (YTR) and roe protein concentrates (RPCs) named freeze-dried concentrate (FDC), boil-dried concentrate (BDC) and steam-dried concentrate (SDC) are shown in Table 1. YTR as a raw material contained 77.3 % moisture, 18.2 % protein, 2.4 % lipid and 1.5 % ash. Heu et al. (2006) reported that skipjack and yellowfin tuna roes contained 71.1–71.2 % moisture, 21.4–21.5 % protein, 2.0–2.1 % lipid and 1.9 % ash, and both tuna roes were no difference in proximate compositions. Intarasirisawat et al. (2011) reported that three different tuna species (skipjack, tongol and bonito) roes contained 72.17–73.03 % moisture, 18.16–20.15 % protein, 3.39–5.68 % lipid and 1.79–2.10 % ash. Iwasaki and Harada (1985) described the proximate composition of raw roe from different species with a wide range in protein content (11.5 % in angler fish to 30.2 % in crab). The chemical composition of roes of 18 fish species was reported and the protein content was estimated to be in the range of 11.5–30.2 % (Iwasaki and Harada 1985). Therefore, yellowfin tuna roe could be source of proteins. The yield of RPCs prepared from YTR were 25.3 % for FDC, 22.2 % for BDC and 22.8 % for SDC, respectively, and uncooked FDC was higher than those of cooked BDC and SDC (P < 0.05). It was due to released soluble protein and other compounds to process drip through cook-dried process (boiling or steaming). Moisture and ash content of RPCs ranged from 4.3 to 5.6 %, and 4.3 to 5.7 %, respectively. Lipid content in RPCs was in the range of 10.6–11.3 %. RPCs had a high protein content accounting for 72.3 % for FDC, 77.3 % for BDC and 76.0 % for SDC, but RPCs were lower protein content than 81.4 % egg white as a positive control (P < 0.05). From the result and reports, difference in moisture and protein content of RPCs was due to processing condition (Mahmoud et al. 2008). Narsing Rao et al. (2012a) was reported that Channa and Lates roes yielded 20.7 % and 22.5 % of protein concentrates possessing 90.2 % and 82.5 % protein, respectively. Protein content in the range of 39.1–43 % and fat content in the range of 14.1–14.8 % were reported in dried and salted roes of hake (Merluccius merluccis) and ling (Molva molva) (Rodrigo et al. 1998). Sathivel et al. (2009) was reported that moisture, protein, ash, and fat contents of spray dried soluble protein powder were 4.5 ± 0.5 %, 67.1 ± 0.2 %, 10 ± 1.0 %, and 18.3 ± 0.6 %, respectively. Chalamaiah et al. (2013) was reported that total ash content of dehydrated and defatted protein concentrates was found to be 5.95 % and 1.95 %, respectively.

Table 1. Proximate composition of yellowfin tuna roe (YTR) and roe protein concentrates (RPCs) prepared by cook-dried process

Sample

Yield1) (g)

Protein yield2) (g)

Moisture (%)

Protein (%)

Lipid (%)

Ash (%)

YTR

100.0

18.2

77.3 ± 0.1

18.2 ± 0.0

2.4 ± 0.1

1.5 ± 0.2

FDC

25.3

18.3

4.3 ± 0.1ab

72.3 ± 0.4c

10.6 ± 0.1a

5.7 ± 0.5a

BDC

22.2

17.2

4.8 ± 0.1a

77.3 ± 1.4b

11.3 ± 0.5a

5.0 ± 0.9a

SDC

22.8

17.3

5.6 ± 1.0a

76.0 ± 1.9b

10.6 ± 0.3a

4.3 ± 0.2a

Egg white

3.0 ± 0.6b

81.4 ± 0.5a

Data are given as mean values ± SD (n = 3)

Values with different letters within the same column are significantly different at P < 0.05 by Duncan’s multiple range test

FDC freeze-dried concentrate, BDC boil-dried concentrate, SDC steam-dried concentrate, respectively

1) Yield is weight (g) of roe protein concentrate obtained from 100 g of raw YTR

2) Protein yield (g) = yield x protein (%)

During the preparation of yellowfin tuna roe concentrate, boiling process drip (BPD) and steaming process drip (SPD) as 2’nd byproduct were generated through cooking process, and data are shown in Table 2. Moisture content of BPD (92.0 %) was higher than that (90.5 %) of SPD (P < 0.05). Protein content of BPD and SPD were 5.8 and 6.4 %, respectively with no significant difference. Starting process water (600 mL) for cooking process was concentrated to 29.6 (BPD) and 18.1 mL (SPD), respectively. Total protein in BPD (500.2 mg/100 g roe) and SPD (365.6 mg/100 g roe) were meaningful difference. This means that boiling process could be easier released to soluble protein and other compounds than steaming process. The proximate composition of fish roe depends on the age of fish, seasons and type of processing (Iwasaki and Harada 1985).

Table 2. Moisture and protein content of process drips obtained from yellowfin tuna roe during cook-dried process

Sample

Moisture (%)

Protein (%)

Volume (mL/100 g roe)

Proteina (mg/mL)

Total protein (mg)

BPD

92.0 ± 0.1a

5.8 ± 0.0a

29.6

16.9b

500.2

SPD

90.5 ± 0.7b

6.4 ± 0.5a

18.1

20.2a

356.6

Data are means ± standard deviation of triplicate determinations

Values with different letters within the same column are significantly different at P < 0.05 by Duncan’s multiple range test

BPD boiling process drip, SPD steaming process drip, respectively

aBased on Lowry’s method (1951)

Total amino acid

YTR and RPCs contained protein ranged from 81.6 to 83.6 % on a dry base were still a considerable amount of fish protein that could be possible to use as protein resource. To assess protein quality, we determined the content of total amino acid in the YTR and RPCs. Total amino acid composition (g/100 g of protein, %) of RPCs from yellowfin tuna roe and positive control (egg white) is shown in Table 3. The major non-essential amino acids of YTR were glutamic acid (12.3 %), aspartic acid (9.1 %) and arginine (6.6 %), respectively. Leucine (8.8 %) and lysine (8.5 %) were the major essential amino acids in YTR. Intarasirisawat et al. (2011) reported that leucine (8.28–8.64 %) and lysine (8.24–8.30 %) were the predominant essential amino acids in defatted tuna roe from skipjack, tongol and bonito. YTR had an essential amino acids/non-essential amino acids ratio of 1.11. From these results, total essential amino acids content of YTR (52.6 %) was higher than total non-essential amino acids content of that (47.4 %). The major non-essential amino acids of RPCs were glutamic acid (13.1–13.2 g/100 g of protein), aspartic acid (8.7–9.2 %) and arginine (6.5–6.6 %), respectively. Among RPCs, glutamic acid (13.1–13.2 %) was the predominant essential amino acid followed by aspartic acid (8.7–9.2 %), leucine (8.5–8.6 %) and lysine (8.5 %). Amino acids namely glutamic acid (13.14 g), aspartic acid (8.08 g) and leucine (7.57 g) were reported per 100 g roe protein of Channa roe protein concentrate (Narsing Rao et al. 2012a).

Table 3. Total amino acid composition (g/100 g protein, %) of yellowfin tuna roe (YTR) and roe protein concentrates (RPCs) prepared by cook-dried process

Amino acid

YTR

FDC

BDC

SDC

Egg white

Protein content (%)

82.4

81.6

82.6

83.6

83.9

Asp

9.1b

8.7c

9.0b

9.2b

11.8a

Thr

5.2a

5.0c

5.1b

5.2a

4.7d

Ser

4.9e

5.6b

5.3d

5.4c

5.7a

Glu

12.3e

13.1d

13.2b

13.2c

14.9a

Pro

6.5a

6.1ab

5.8b

5.8b

3.7c

Gly

5.6a

4.9b

5.1b

5.1b

4.0c

Ala

5.6b

6.6a

6.4a

6.4a

6.6a

Cys

0.8a

0.7a

0.7b

0.8a

0.7a

Val ∮†

5.9c

6.3b

6.5b

6.4b

8.2a

Met ∮†

4.0a

2.9b

2.9c

2.8b

2.0c

Ile ∮†

5.9b

5.4c

5.5c

5.4c

6.2a

Leu ∮†

8.8b

8.6c

8.6c

8.5c

9.2a

Tyr

2.5c

3.4a

3.1b

3.0b

0.2d

Phe ∮†

4.3e

4.4d

4.6b

4.6c

6.4a

His

3.4a

3.4a

3.2b

3.2b

2.7c

Lys

8.5a

8.5a

8.5a

8.5a

8.2b

Arg

6.6a

6.6a

6.6a

6.5a

4.8b

TAA

99.9

100.2

100.1

100.0

100.0

EAA

52.6

51.1

51.5

51.1

52.4

EAA/NEAA

1.11

1.04

1.06

1.00

1.10

Hydrophobic amino acid

46.6

45.2

45.4

45.0

46.3

Data are means ± standard deviation of duplicate determination

Values with different letters within the same row are significantly different at P < 0.05 by Duncan’s multiple range test

TAA total amino acid, EAA essential amino acids, NEAA non essential amino acids

Essential amino acids for infant

Hydrophobic amino acids

RPCs had essential amino acid/non-essential amino acid ratio in range of 1.00–1.06. From this result, essential amino acid/non-essential amino acid ratio of PRCs was lower than that (1.10) of egg white, but it was similar to the value reported Heu et al. (2006) for yellowfin tuna roe. Lysine is often considered a first limiting amino acid for cereal food. Therefore, it needs to be emphasized that the RPCs had a higher content of lysine (8.5 %) than egg white (8.2 %) (P < 0.05). The lysine content of RPCs was 8.5 % which was higher than that reported for Channa (6.94 %) and Lates (6.86 %) roe protein concentrate (Narsing Rao et al. 2012a).

YTR and RPCs had hydrophobic amino acids ranged from 45.0 to 46.6 %. Hydrophobicity plays an important positive role in determining emulsifying properties (Chalamaiah et al. 2013). FitzGerald and O’Cuinn (2006) reported that bitterness of protein hydrolysate is associated with the release of peptides containing hydrophobic amino acid residues. Thus, RPCs could possibly be a dietary protein supplement to poorly balanced dietary proteins exhibiting to low bitterness.

Mineral

Mineral (K, S, Na, P, Fe, Mg, Zn, Ca, Fe, Mn, Cu, Pb, Cd, Cr and Ni) composition was determined to identify the nutritional properties as a food compounds. Mineral content of YTR and RPCs is presented in Table 4. K content was the most predominant mineral in YTR (456.0 mg/100 g of sample), followed by P, Na and Mg (437.0, 167.0 and 29.0 mg/100 g, respectively). Minor minerals were Ca and Zn (11.0 and 8.0 mg/100 g, respectively). Heu et al. (2006) reported that predominant mineral in YTR was P (371.5 mg/100 g) followed by K and Ca (325.4 and 61.9 mg/100 g, respectively). Na content of YTR (167.0 mg/100 g) was very lower than that (2473 and 2348 g/100 g, respectively) of dried salted roes of hake Merluccius merluccius and ling Molva molva reported Rodrigo et al. (1998). This high Na content is clearly due to the salting process used to obtain the commercial product. FDC had significantly higher K, Na and P content (1179.9, 376.2 and 257.7 mg/100 g of sample, respectively) compared with those of BDC and SDC (P < 0.05). Similar K, P and Na contents in defatted-tuna roes were found in salmon roe (Bekhit et al. 2009). P content has been generally associated with the phospholipid content and the presence of phosphoprotein (Mahmoud et al. 2008; Matsubara et al. 2003). The highest S content was found in egg white (1341.3 mg/100 g) as a positive control (P < 0.05). Bekhit et al. (2009) reported that salmon roe had S content of 1647–2443 mg/kg (wet basis). Catfish roe protein powder had S content of approximately 0.56 mg/kg (Sathivel et al. 2009). The result implied that tuna roe had a high content of sulfur-containing compounds, which could undergo decomposition during storage, causing off-odor. Fe (9.7–12.9 mg/100 g of sample), Cu (0.4–0.5 mg/100 g of sample), Mn (0.1–0.2 mg/100 g of sample) and Mg (59.1–70.6 mg/100 g of sample) were minor minerals in RPCs. Fe and Cu are classified as the essential trace elements required for physiological and metal metabolic processes of marine organisms (Thanonkaew et al. 2006). Metal ions (Fe, Cu, Mn and Mg) might serve as catalysts for lipid oxidation, and have been shown to exhibit pro-oxidant activity (Thanonkaew et al. 2006). However, Fe and P contents of all samples were lower than those of catla, carp and rohu roes (Balaswamy et al. 2009). The variation in the mineral composition of marine foods is closely related to seasonal and biological differences, area of catch, processing methods, food source and environmental conditions (salinity, temperature and contaminant) (Alasalvar et al. 2002). According to Korean Food Standards Codex, Pb and Cd do not exceed 0.5 and 0.1 mg/kg for fish roe. YTR and RPCs could serve as safety and mineral source.

Table 4. Mineral contents (mg/100 g sample) of yellowfin tuna roe (YTR) and roe protein concentrates (RPCs) prepared by cook-dried process

Sample

YTR

FDC

BDC

SDC

Egg white

Moisture (%)

77.3

4.3ab

4.8a

5.6a

3.1b

Mineral

K

456.0 ± 2.0c

1179.9 ± 8.3a

761.6 ± 67.4b

758.9 ± 200.3b

787.0 ± 13.2b

S

992.3 ± 92.6b

858.2 ± 10.3c

818.1 ± 141.8bc

1341.3 ± 1.2a

Na

167.0 ± 1.0d

376.2 ± 2.1b

287.2 ± 17.5c

268.3 ± 55.5c

1015.8 ± 8.8a

P

437.0 ± 3.0a

257.7 ± 2.8b

223.4 ± 13.4c

208.5 ± 35.2c

92.5 ± 0.4d

Mg

29.0 ± 0.0c

66.8 ± 0.4a

70.6 ± 2.5a

59.1 ± 7.7a

Zn

8.0 ± 0.0c

45.0 ± 0.3b

49.9 ± 0.4a

48.4 ± 3.5a

Ca

11.0 ± 0.0c

33.5 ± 0.3b

58.6 ± 12.2a

32.3 ± 3.7b

65.2 ± 0.6a

Fe

9.8 ± 0.1b

12.9 ± 0.2b

9.7 ± 0.8ab

0.6 ± 0.0a

Mn

0.1 ± 0.0a

0.2 ± 0.0b

0.1 ± 0.0b

0.0 ± 0.0b

Heavy metal

Cu

0.5 ± 0.0a

0.5 ± 0.1a

0.4 ± 0.1a

0.1 ± 0.0b

Pb

0.2 ± 0.1a

0.1 ± 0.0a

0.3 ± 0.1a

0.0 ± 0.0a

Cd

0.1 ± 0.0a

0.1 ± 0.0a

0.1 ± 0.0a

0.0 ± 0.0b

Cr

0.1 ± 0.0a

0.2 ± 0.1a

0.2 ± 0.1a

0.1 ± 0.0a

Ni

0.0 ± 0.0a

0.1 ± 0.1a

0.0 ± 0.0a

0.0 ± 0.0a

–; not determined

Data are means ± standard deviation of three samples

Values with different letters within the same row are significantly different at P < 0.05 by Duncan’s multiple range test

Hunter color

RPCs were light yellow in color and the L, a, b values are listed in Table 5. FDC was the lightest with L* value of 59.2. L* value of BDC and SDC (55.7 and 55.4, respectively) were no significant (P > 0.05). a* value of FDC (6.5) was higher than that of BDC (5.2) and SDC (5.3). FDC had the highest b* value (18.6) than that (17.8 and 17.4, respectively) of BDC and SDC (P < 0.05). However, total color change (ΔE) value is not significantly difference among the RPCs. (P > 0.05). Whiteness values of FDC (54.7), BDC (52.0) and SDC (51.8) were observed with no significant (P > 0.05). Sathivel et al. (2009) reported that the catfish roe soluble protein powder was light and yellow in color (L* = 71.7; a* = 3.9; b* = 28.8).

Table 5. L*, a* and b* color values and whiteness of concentrates (FDC, BDC and SDC) by cook-dried process

Hunter color

FDC

BDC

SDC

L*

59.2 ± 0.1a

55.7 ± 3.7b

55.4 ± 1.9b

a*

6.5 ± 0.1a

5.2 ± 0.6b

5.3 ± 0.4b

b*

18.6 ± 0.0a

17.8 ± 0.1b

17.4 ± 0.1c

ΔE

42.3 ± 0.1a

45.0 ± 3.4a

45.1 ± 1.8a

Whiteness

54.7 ± 0.1a

52.0 ± 3.5a

51.8 ± 1.8a

Data are means ± standard deviation of triplicate determinations

Values with different letters within the same row are significantly different at P < 0.05 by Duncan’s multiple range test

SDS-PAGE

SDS-PAGE patterns of FDC, BDC and SDC prepared from yellowfin tuna roe and their 2’nd byproduct (BPD and SPD, respectively) are shown in Fig. 2. Actinin band of FDC was observed around 120 K. The major bands of FDC observed at molecular weight around 97 K. FDC exhibited two clear protein bands in the range of 75–100 K. Protein bands at approximately 97 K could be vitellin like protein, which was found in skipjack, tongol, bonito roes (Intarasirisawat et al. 2011), chicken egg yolk (DeMan 1999) and salmon Oncorhynchus keta and sturgeon Acipenser transmontanus roes (Al-Holy and Rasco 2006). Protein bands in range of 50–37 K and 15 K were observed. They could be the actin, troponin-T and myosin light chain (MLC), respectively. Protein bands of egg white (EW) were observed that in range of 75–100 K, 37–50 K and around 15 K, respectively. More clearance actin band was observed on EW than that of FDC. Whereas, vitellin like protein band of FDC was more clear than that of EW. SDS-PAGE patterns observed for BDC and SDC were comparable. Above 250 K of protein band was clearly observed on BDC and SDC. However, actinin was not found both of them. Protein bands of 170, 95, and 55 K was reported in Channa and Lates roe protein concentrate (Narsing Rao et al. 2012a). Sathivel et al. (2009) observed the presence of four abundant proteins with molecular weights between 40 and 100 K in spray dried catfish roe protein powder. The major bands of dehydrated and defatted egg protein concentrates from mrigal observed occurred at molecular weight (MW) of 97 K (Chalamaiah et al. 2013). In case of BDC and SDC, band patterns in range of 15–25 K more reduced than those of FDC. Because association and aggregation of protein on low molecular protein was occurred due to cooking process which caused protein degradation and soluble protein like a sarcoplasmic protein was released from YTR. Released soluble protein was found on BPD and SPD. Their major protein band was 50 K. Low molecular soluble protein was observed in range of 25–50 K caused by degradation of high molecular protein.

Fig. 2. SDS-PAGE patterns of roe protein concentrates (RPCs) and roe process drips prepared from yellowfin tuna roe

## Conclusion

Fish roe, a by-product in fishery industry, can be utilized as a low cost source of protein for value addition. Production of roe protein concentrate from yellowfin tuna roe is a simple and economical process. This study demonstrated that is feasible to produce concentrates from yellowfin tuna roe by cook-dried process. The roe protein concentrates were found to be rich in protein with essential amino acid. Fish roe protein concentrates may potentially serve as a good source of protein with desirable functional properties. Therefore, these protein concentrates could be used as protein supplements and functional ingredients in human diets.

## Acknowledgements

This research was supported by Basic Science Research Program through the National Research Foundation of Korea(NRF) funded by the Ministry of Education(NRF-2014R1A1A4A01008620).

## Competing interests

The authors declare that they have no competing interests.

## Authors’ contributions

HJL and SHP carried out the preparation of protein concentrates, participated in the analysis of chemical compositions and drafted the manuscript. ISY, G-WL and YJK participated in searching and screening references and performed the statistical analysis and carried out the SDS-PAGE. J-SK and MSH conceived of the study, and participated in its design and coordination and helped to draft the manuscript. All authors read and approved the final manuscript.

## References

1.

Alasalvar C, Taylor KDA, Zubcov E, Shahidi F, Alexis M. Differentiation of cultured and wild sea bass (Dicentrarchus labrax): total lipid content, fatty acid and trace mineral composition. Food Chem. 2002; 79:145-50

2.

Al-Holy MA, Rasco BA. Characterisation of salmon (Oncorhynchus keta) and sturgeon (Acipenser transmontanus) caviar proteins. J Food Biochem. 2006; 30:422-8

3.

AOAC (Association of Analytical Chemists). Official Methods of Analysis. 1995; 16 Washington DC: Association of Analytical Chemists. p. 69-74.

4.

Bala BK, Mondol MRA. Experimental investigation on solar drying of fish using solar tunnel dryer. Drying Technol. 2001; 19:427-36

5.

Balaswamy K, Prabhakara Rao P, Narsing Rao G, Govardhana Rao D, Jyothirmayi T. Physicochemical composition and functional properties of roes from some fresh water fish species and their application in some foods. J Environ Agric Food Chem. 2009; 8:704-10.

6.

Bekhit A, Morton JD, Dawson CO, Zhao JH, Lee HYY. Impact of maturity on the physicochemical and biochemical properties of chinook salmon roe. Food Chem. 2009; 117:318

7.

Bellagha S, Amami E, Farhat A, Kechaou N. Drying kinetics and characteristic drying curve of lightly salted sardine (Sardinella aurita). Drying Technol. 2002; 20:1527-38

8.

Chalamaiah M, Narsing Rao G, Rao DG, Jyothirmayi T. Protein hydrolysates from meriga (Cirrhinus mrigala) egg and evaluation of their functional properties. Food Chem. 2010; 120:652-7

9.

Chalamaiah M, Balaswamy K, Narsing Rao G, Prabhakara Rao PG, Jyothirmayi T. Chemical composition and functional properties of mrigal (Cirrhinus mrigala) egg protein concentrates and their application in pasta. J Food Technol. 2013; 50:514-20

10.

Cordero-de-los-Santos MY, Osuna-Castro JA, Borodanenko A, Paredes-López O. Physicochemical and functional characterisation of amaranth (Amaranthus hypochondriacus) protein isolates obtained by isoelectric precipitation and micellisation. Food Sci Technol Int. 2005; 11:269-80

11.

DeMan JM. In: DeMan JM, editor. Proteins. Principles in Food Chemistry. 1999; Gaithersburg: Aspen Publishers Inc. p. 111-62

12.

Duan ZH, Zhang M, Tang J. Thin layer hot-air drying of bighead carp. Fish Sci. 2004; 23:29-32.

13.

FitzGerald RJ, O’Cuinn GO. Enzymatic debittering of food protein hydrolysates. Biotechnol Adv. 2006; 24:234-7

14.

Heu MS, Kim HS, Jung SC, Park CH, Park HJ, Yeum DM, Park HS, Kim CG, Kim JS. Food component characteristics of skipjack (Katsuwonus pelamis) and yellowfin tuna (Thunnus albacares) roes. J Kor Fish Soc. 2006; 39:1-8.

15.

Intarasirisawat R, Benjakul S, Visessanguan W. Chemical compositions of the roes from skipjack, tongol and bonito. Food Chem. 2011; 124:1328-34

16.

Iwasaki M, Harada R. Proximate and amino acid composition of the roe and muscle of selected marine species. J Food Sci. 1985; 50:1585-7

17.

Klomklao S, Benjakul S, Kishimura H. Optimum extraction and recovery of trypsin inhibitor from yellowfin tuna (Thunnus albacores) roe and its biochemical properties. Int J Food Sci Technol. 2013; 49:168-73

18.

Laemmli UK. Cleavage of structural proteins during the assembly of the head of bacteriophage T4. Nature. 1970; 227:680-5

19.

Lowry OH, Rosebrough NJ, Farr AL, Randall RJ. Protein measurement with the Folin phenol reagent. J Biol Chem. 1951; 193:265-75

20.

Mahmoud KA, Linder M, Fanni J, Parmentier M. Characterisation of the lipid fractions obtained by proteolytic and chemical extractions from rainbow trout (Oncorhynchus mykiss) roe. Process Biochem. 2008; 43:376-83

21.

Matsubara T, Nagae M, Ohkubo N, Andoh T, Sawaguchi S, Hiramatsu N. Multiple vitellogenins and their unique roles in marine teleosts. Fish Physiol Biochem. 2003; 28:295-9

22.

Ministry of Ocean and Fisheries. 2014. Yearbook of marine resource. Retrieved from http://www.mof.go.kr/article/view.do?articleKey=5197&boardKey=32&menuKey=396&currentPageNo=1. Accessed 26 Jan 2015.

23.

Narsing Rao G, Balaswamy K, Satyanarayana A and Prabhakara Rao P. Physico-chemical, amino acid composition, functional and antioxidant properties of roe protein concentrates obtained from Channa striatus and Lates calcarifer. Food chem. 2012a; 132:1171–1176

24.

Narsing Rao G, Prabhakara Rao P, Satyanarayana A and Balaswamy K. Functional properties and in vitro antioxidant activity of roe protein hydrolysates of Channa striatus and Labeo rohita. Food Chem. 2012b;135, 1479–1484

25.

Pires C, Costa S, Batista AP, Nunes MC, Raymundo A, Batista I. Properties of protein powder prepared from Cape hake by-products. J Food Eng. 2012; 108:268-75

26.

Rodrigo J, Ros G, Periago MJ, Lopez C, Ortuiio J. Proximate and mineral composition of dried salted roes of hake (Merluccius merluccius, L.) and ling (Molva molva, L.). Food Chem. 1998;63:221–5.

27.

Sathivel S, Bechtel PJ. Properties of soluble protein powders from Alaska pollock (Theragra chalcogramma). Int J Food Sci Technol. 2006; 41:520-9

28.

Sathivel S, Yin H, Bechtel PJ, King JM. Physical and nutritional properties of catfish roe spray dried protein powder and its application in an emulsion system. J Food Eng. 2009; 95:76-81

29.

Thanonkaew A, Benjakul S, Visessanguan W, Decker EA. The effect of metal ions on lipid oxidation, colour and physicochemical properties of cuttlefish (Sepia pharaonis) subjected to multiple freeze-thaw cycles. Food Chem. 2006; 95:591-9